Designing ISO / IEC 17025: 2017 – Based Laboratory Quality Manual : A Case of Laboratory of Environmental Engineering in Andalas University

Deri Kurniadi, Elita Amrina, . Alfadhlani

Abstract


Testing Laboratory of the Department of Environmental Engineering at Andalas University in maintaining the quality and trust of customers will carry out accreditation. One of the requirements in the accreditation process is the existence of a laboratory quality manual. However, the Testing Laboratory of the Department of Environmental Engineering at Andalas University does not yet have a quality manual that is following ISO / IEC 17025: 2017. Therefore the research aims to design a quality manual for ISO / IEC 17025: 2017 based laboratories in the Testing Laboratory of the Department of Environmental Engineering at Andalas University. The method used in this study is the PDCA framework (Plan, Do, Check, Action). The results showed that the design results of each of the requirements contained in each ISO / IEC 17025: 2017 clause were appropriate.


Keywords


Quality Manual, Laboratory, PDCA

Full Text:

PDF

References


Alkhafaji, A. F. (2003). Strategic Management: Formulation, Implementation, and Control in a Dynamic. New York: Routledge.

Anthapur, S. K. (2012). Walkability and Pedestrian Facilities in Asian Cities. New Delhi: CAI for Asian Cities.

Arcaro J. (1995). Quality in Educatio, An Implementation Handbook. Florida: St. Lucie Press

Bettencourt, C., Velho, J.S. & Almeida, P.A. (2011). Biology teachers’ perceptions about Science-Technology-Society (STS) education. Procedia Social and Behavioral Sciences, 15, hlm. 3148–3152

Buku Acuan Standar Mutu. 2008. SNI-ISO-IEC-17025-2008-Standard. Badan Standardisasi Nasional, 2015 (http://www.bsn.go.id)

Capryani, A (2017). Perancangan Dokumentasi Sistem Manajemen Pada Laboratorium Mekatronika UNS Berdasarkan SNI ISO/IEC 17025 : 2008. Performa (2017) Vol. 16 No.1: 54-61.

Crosby, P. B. 1979. Quality Is Free. New York: New American Library

Crosby, P.B. 1979. Quality is Free: The Art of Marking Quality Certain. New. York: McGraw-Hill

Deming, Shewhart.2008. Journal : Manajemen PDCA (Plan-Do-Check -Action). Perpustakaan Online Indonesia. Jakarta. Website: http://organisasi.org/manajemen-pdca-plan-do-check-actionwalter shewhart- w-edwards-deming

Deming, W. E. 1982. Guide to Quality Control. Cambirdge: Massachussetts Institute Of Technology.

Dina, dan Wastra. A. R. Efektivitas Penerapan Sistem Manajemen Mutu SNI ISO/IEC 17025 : 2008 Di Laboratorium Benih. Jurnal Agribisnis, Vol. 7, No. 2, Desember 2013, [ 157 - 172 ].

Emda, A. (2014). Laboratorium Sebagai Sarana Pembelajaran Kimia Dalam Meningkatkan Pengetahuan Dan Ketrampilan Kerja Ilmiah. Lantanida Journal, Vol. 2 No. 2, 2014

Fatchiyah .Tata Kelola Laboratorium Berbasis. SNI ISO/IEC 17025:2008.. Dept. of Biology, Faculty of Science.

Garvin, D. A. (2002). Managing Quality. New York: The Free Press

Grochau, I. H dan Caten, S.C. 2012. A Process Approach to ISO/IEC 17025 In The Implementation of A Quality Management System In Testing Laboratories. Accreditation and Quality Assurance. 17 (5): 519-527

Gunamantha, I. M (2017). Pelatihan SNI SO 17025: 2008 Bagi Tenaga Laboratorium. International Journal of Community Service Learning. Vol.1 (1) 39-42.

Hadi, A. (2007) Pemahaman dan Penerapan ISO/IEC 17025:2005 Persyaratan Umum Kompetensi Laboratorium Pengujian dan Laboratorium Kalibrasi. PT. Gramedia Pustaka Utama, Jakarta.

Hindayani, A (2017). Validasi Metode Berdasarkan ISO/IEC 17025:2017 dan Aplikasinya Pada Pengukuran pH Bufer Ftalat Menggunakan Elektroda Gelas dengan Teknik Dua Titik Kalibrasi. Laboratorium Metrologi Kimia (LMK), Pusat Penelitian Metrologi-Lembaga Ilmu Pengetahuan Indonesia (P2M-LIPI)

Juran, J.M. and Frank M. Gryna; “Quality Planning and Analysis”, Third Edition, Mc Graw, New York, 1993

Kanitvittaya S, Suksai U, Suksripanich O (2016). Laboratory quality improvement in Thailand’s northernmost provinces. International Journal of Health Care Quality Assurance

Malkoc, E. dan Neuteboom, W ( 2007). The current status of forensic science laboratory accreditation in Europe. Article in Forensic Science International • May 2007

Masripah, (2011). Evaluasi Audit Internal LUB PTBN 2008 - 2011 Untuk Menilai Efektifitas Implementasi ISO/IEC 17025:2005. Pusat Teknologi Bahan Bakar Nuklir – BATAN Kawasan Puspiptek Tangerang Selatan.

Nasution, M. N (2001).Manajemen Mutu Terpadu (Total Quality Management), Penerbit Ghalia Indonesia.Jakarta

Pambudi, C. S. (2016). Analisa Pengaruh Persyaratan Teknis Dan Persyaratan Manajemen Terhadap Kesiapan Penerapan ISO/IEC 17025 Di PT. Santoso Teknindo.

Pelatihan Penyusunan Dokumentasi Sistem Manajemen Laboratorium SNI ISO/IEC 17025:2008. Badan Standardisasi Nasional, 2015 (http://www.bsn.go.id)

Persyaratan Umum Kompetensi Laboratorium Pengujian dan Laboratorium Kalibrasi ISO/IEC 17025;2008. Standar Nasional Indonesia

Persyaratan Umum Kompetensi Laboratorium Pengujian dan Laboratorium Kalibrasi ISO/IEC 17025;2017. Standar Nasional Indonesia

Poerwanto, G. H. (2012). Manajemen Kualitas. Jakarta: PT Gramedia Pustaka Utama.

Ratseou E dan Ramphal. 2014 The impact of laboratory quality assurance standards on laboratory operational performance. African Journal of Hospitally, Tourism and Leisure. 3(2) : 1-13

Silva, V. V. M. dan Ribeiro, J. L. D. "Obtaining laboratory accreditation – required activities", International Journal of Health Care Quality Assurance

Sipahutar, R. (2015). Penerapan Sistem Manajemen Mutu pada Laboratorium Preparasi PLTR-BATAN. Jurnal Ilmiah Faktor Exacta. Vol. 4 No. 3 September 2011

Sistem Penjaminan Mutu Internal – Sekolah Tinggi Multi Media (SPMI-STMM) 2015 – Yogyakarta

Sutrisno, E. (2010). Manajemen Sumber Daya Manusia. Edisi Pertama. Cetakan Pertama. Jakarta : Penerbit Kencana

Wangkahat, K. Nookhai, S. dan Pobkeeree, V. (2012),"Public health laboratory quality management in a developing country", International Journal of Health Care Quality Assurance, Vol. 25 Iss 2 pp. 150 - 160

Yonatan, Feliando, J, Palit, Christian, H. Upaya Peningkatan Kualitas Dengan Metode PDCA Di PT ASKI / Jurnal Titra, Vol. 3, No.2, Juli 2015, pp. 283-28




DOI: http://dx.doi.org/10.52155/ijpsat.v19.1.1534

Refbacks

  • There are currently no refbacks.


Copyright (c) 2020 Deri Kurniadi, Elita Amrina, . Alfadhlani

Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 International License.